• <optgroup id="wmwca"><u id="wmwca"></u></optgroup>

    公司新聞

    反應釜維修及保養

    發布時間:2017/6/2 10:28:59

    磁力反應釜維修及保養

    Maintenance and maintenance of magnetic reaction kettle

      1、磁力反應釜各潤滑部位應經常注油。

    1, the magnetic reaction tank lubrication parts should always oiling.

      2、磁力反應釜墻板密封部不應有原料泄露現象。

    2, the magnetic reaction kettle wallboard sealing parts should not have leakage of raw materials.

      3、磁力反應釜皮帶松緊程度適宜,定期檢查調整或更換。

    3, magnetic reaction tank belt tightness degree suitable, regular inspection, adjustment or replacement.

      4、磁力反應釜蒸汽管道不允許泄露,機器停用時應關閉閥門,并保證安全閥壓力表的可靠性。

    4. The steam pipe of the magnetic reaction kettle is not allowed to leak. When the machine is deactivated, the valve should be closed, and the reliability of the safety valve pressure gauge shall be guaranteed.

      5、剛使用可能出現黑料現象主要是機器運轉后沒有及時調緊產生軸與填料間的間隙,母料返流間隙填補空間加熱后產生老化變成黑料,在真空時就容易將黑料抽進攪拌缸內。此時請將主軸上的填料箱(兩邊四組)上半片打開(松開內六角螺絲),將里面的四氟填料取出后,前面的四氟圈清洗干凈,后面重新換上新的填料調緊。一天檢查一次一有松動立即調整填料間隙(不要調死)。

    5, just use may appear black material phenomenon is mainly machine not timely tightening axial gap filler between the masterbatch reflux gap filling space heating after aging into a black material in vacuum is easy to be pumped into the black material mixing cylinder. Please put the stuffing box on the main shaft (at both sides of the four group) open half piece (loosen inner six angle screw), which will be out in front of the PTFE packing, PTFE ring clean, back again a new tight packing. Check once a day, there is a loose, immediately adjust the packing gap (do not tune to death).

      6、本機運行六個月后進行大修,檢查易損壞程度,作出釋放調整及更換。

    6, the machine running six months after the overhaul, check the degree of damage, to release, adjust and replace.

      7、注意:

     。1)磁力反應釜加熱系統屬于高溫介質,使用前應小心謹慎,切忌使用手查測管路及本機臺是否加熱以免燙傷。

     。2)磁力反應釜電器附近應設有警示牌。


    7, pay attention to:

    (1) the heating system of a magnetic reaction kettle belongs to a high temperature medium. It should be careful before use. Do not use the hand to check whether the pipe and the machine are heated so as not to scald.

    (2) a warning plate shall be provided near the electric appliance of the magnetic reaction kettle.


    視頻

    快速查找產品

    聯系方式

    上海穗興機電發展有限公司

    地址:上海市寶山區金勺路1438號

    郵箱:shsuida@126.com

    021-36551996

    021-36551997

    shsuida@126.com

    shsuida@126.com

    GOGO欧美裸体艺术大胆